DOI: https://doi.org/10.9767/bcrec.15.1.5227.55-65

Facile Investigation of Ti3+ State in Ti-based Ziegler-Natta Catalyst with A Combination of Cocatalysts Using Electron Spin Resonance (ESR)

Center of Excellence on Catalysis and Catalytic Reaction Engineering, Department of Chemical Engineering, Faculty of Engineering, Chulalongkorn University, Bangkok 10330, Thailand

Received: 21 Jun 2019; Revised: 28 Aug 2019; Accepted: 3 Sep 2019; Available online: 28 Feb 2020; Published: 1 Apr 2020.
Editor(s): Istadi Istadi
Open Access Copyright (c) 2020 by Authors, Published by BCREC Group under http://creativecommons.org/licenses/by-sa/4.0.
Fulltext View|Download

Citation Format:
Cover Image
Abstract

This study aims to investigate the influences of a combination of cocatalysts including triethylaluminum (TEA) and tri-n-octylaluminum (TnOA) for activation of a commercial Ti-based Ziegler-Natta catalyst during ethylene polymerization and ethylene/1-hexene copolymerization on the change in Ti3+ during polymerization. Thus, electron spin resonance (ESR) technique was performed to monitor the change in Ti3+ depending on the catalyst activation by a single and combination of cocatalyst. It revealed that the amount of Ti3+ played a crucial role on both ethylene polymerization and ethylene/1-hexene copolymerization. For ethylene polymerization, the activation with TEA apparently resulted in the highest catalytic activity. The activation with TEA+TnOA combination exhibited a moderate activity, whereas TnOA activation gave the lowest activity. In case of ethylene/1-hexene copolymerization, it revealed that the presence of 1-hexene decreased activity. The effect of different cocatalysts tended to be similar to the one in the absence of 1-hexene. The decrease of temperature from 80 to 70 °C in ethylene/1-hexene copolymerization tended to lower catalytic activity for TnOA and TEA+TnOA, whereas only slight effect was observed for TEA system. The effect of different cocatalyst activation on the change of Ti3+ state of catalyst was elucidated by ESR measurement. It appeared that the activation of catalyst with TEA+TnOA combination essentially inhibited the reduction of Ti3+ to Ti2+ leading to lower activity.  Furthermore, the polymer properties such as morphology and crystallinity can be altered by different cocatalysts. Copyright © 2020 by Authors, Published by BCREC Group. This is an open access article under the CC BY-SA License (https://creativecommons.org/licenses/by-sa/4.0).

Keywords: Ethylene polymerization; Ziegler-Natta catalyst; Cocatalysts; Titanium oxidation state; Electron spin resonance
Funding: Thai Polyethylene co., Ltd. ; Mahidol University

Article Metrics:

Article Info
Section: Original Research Articles
Language : EN
Recent articles
A Review Paper on Heterogeneous Fenton Catalyst: Types of Preparation, Modification Techniques, Factors Affecting the Synthesis, Characterization, and Application in the Wastewater Treatment One-pot Synthesis of Carbon-doped TiO2 with Bimetallic Ni-Ag co-catalysts in Photodegradation of Methylene Blue under UV and Visible Irradiation Catalytic Dehydration of Ethanol over W/TiO2 Catalysts Having Different Phases of Titania Support Activity and Stability of Immobilized Lipase for Utilization in Transesterification of Waste Cooking Oil Dynamic Model-Free and Model-Fitting Kinetic Analysis during Torrefaction of Oil Palm Frond Pellets Frontmatter (Front Cover, Editorial Team, Indexing, and Table of Contents) Backmatter (Publication Ethics, Copyright Transfer Agreement Form) More recent articles
  1. Lee, T., Kim, W.-K., Lee, Y., Ryou, M.-H., Lee, Y. M. (2014). Effect of Al2O3 coatings prepared by RF sputtering on polyethylene separators for high-power lithium ion batteries. Macromolecular Research, 22: 1190-1195
  2. Jeon, M., Han, C. J., Kim, S. Y. (2006). Polymerizations of propylene with unsymmetrical (α-diimine) nickel (II) catalysts. Macromolecular Research, 14: 306-311
  3. Chien, J. C., He, D. (1991). Olefin copolymerization with metallocene catalysts. III. Supported metallocene/methylaluminoxane catalyst for olefin copolymerization. J. Polymer Sci. Part A: Polymer Chem., 29: 1603-1607
  4. Chien, J. C., He, D. (1991). Olefin copolymerization with metallocene catalysts. I. Comparison of catalysts. J. Polym. Sci. Part A: Polym. Chem., 29: 1585-1593
  5. Kaminsky, W. (1996). New polymers by metallocene catalysis. Macromol. Chem. Phys., 197: 3907-3945
  6. Kaivalchatchawal, P., Samingprai, S., Shiono, T., Praserthdam, P., Jongsomjit, B. (2012). Effect of Ga-and BCl3-modified silica-supported [t-BuNSiMe2 (2,7-t-Bu2Flu)] TiMe2/MAO catalyst on ethylene/1-hexene copolymerization. Eur. Polym. J., 48: 1304-1312
  7. Lee, S., Choi, K.Y. (2017). Ethylene polymerization over metallocene catalysts supported on highly fibrous silica nanoparticles. Macromol. Reac. Eng., 11: 1600027
  8. Mohamadnia, Z., Ahmadi, E., Haghighi, M.N., Farandpour, A., Rezazadah, Z., Fallahi, M. (2015). Preparation of LLDPE through tandem ethylene polymerization using chromium and zirconium catalysts. Iran. Polym. J., 24: 621-628
  9. Gagieva, S.C., Tuskaev, V.A., Fedyanin, I.V., Buzin, M.I., Vasil’ev, V.G., Nikiforova, G.G., Afanas’ev, E.S., Zubkevich, S.V., Kurmaev, D.A., Kolosov, N.A., Mikhaylik, E.S. (2017). Novel titanium (IV) diolate complexes: Synthesis, structure and catalytic activities in ultra-high molecular weight polyethylene production. J. Organometal. Chem., 828: 89-95
  10. Kaminsky, W. (2012). Discovery of methylaluminoxane as cocatalyst for olefin polymerization. Macromolecules, 45: 3289-3297
  11. Noristi, L., Barbè, P.C., Baruzzi, G. (1991). Effect of the internal/external donor pair in high‐yield catalysts for propylene polymerization, 1. Catalyst‐cocatalyst interactions. Die Makromolekulare Chemie: Macromol. Chem. Phys., 192: 1115-1127
  12. Mori, H., Iguchi, H., Hasebe, K., Terano, M. (1997). Kinetic study of isospecific active sites formed by various alkylaluminiums on MgCl2‐supported Ziegler catalyst at the initial stage of propene polymerization. Macromol. Chem. Phys., 198: 1249-1255
  13. Senso, N., Praserthdam, P., Jongsomjit, B., Taniike, T., Terano, M. (2011). Effects of Ti oxidation state on ethylene, 1-hexene comonomer polymerization by MgCl 2-supported Ziegler–Natta catalysts. Polymer Bulletin., 67: 1979-1989
  14. Garoff, T., Mannonen, L., Väänänen, M., Eriksson, V., Kallio, K., Waldvogel, P. (2010). Chemical composition distribution study in ethylene/1‐hexene copolymerization to produce LLDPE material using MgCl2‐TiCl4‐based Ziegler‐Natta catalysts. J. Appl. Polym. Sci., 115: 826-836
  15. Hongmanee, G., Sripothongnak, S., Jongsomjit, B., Praserthdam, P. (2014). Observation on different reducing power of cocatalysts on the Ziegler–Natta catalyst containing alkoxide species for ethylene polymerization. J. Appl. Polym. Sci., 131: 40884(1-5)
  16. Nooijen, G. (1994). On the importance of diffusion of cocatalyst molecules through heterogeneous ziegler/natta catalysts. Eur. Polym. J., 30: 11-15
  17. Shan, C.L.P., Chu, K.J., Soares, J., Penlidis, A. (2000). Using alkylaluminium activators to tailor short chain branching distributions of ethylene/1‐hexene copolymers produced with in‐situ supported metallocene catalysts. Macromol. Chem. Phys., 201: 2195-2202
  18. Senso, N., Khaubunsongserm, S., Jongsomjit, B., Praserthdam, P. (2010). The influence of mixed activators on ethylene polymerization and ethylene/1-hexene copolymerization with silica-supported Ziegler-Natta catalyst. Molecules, 15: 9323-9339
  19. Pinyocheep, J., Ayudhya, S.K.N., Jongsomjit, B., Praserthdam, P. (2012). Observation on inhibition of Ti3+ reduction by fumed silica addition in Ziegler-Natta catalyst with in situ ESR. Journal of Industrial and Engineering Chemistry, 18: 1888-1892
  20. Risse, T., Schmidt, J., Hamann, H., Freund, H.J. (2002). Direct Observation of Radicals in the Activation of Ziegler–Natta Catalysts. Angewandte Chemie International Edition, 41: 1517-1520
  21. Xiong, L.-B., Li, J.-L., Yang, B., Yu, Y. (2012). Ti3+ in the surface of titanium dioxide: generation, properties and photocatalytic application. J. Nanomater., 2012, 1-13
  22. Koshevoy, E.I., Mikenas, T.B., Zakharov, V. A., Shubin, A.A., Barabanov, A.A. (2016). Electron Paramagnetic Resonance Study of the Interaction of Surface Titanium Species with AlR3 Cocatalyst in Supported Ziegler–Natta Catalysts with a Low Titanium Content. J. Physical Chem. C., 120: 1121-1129
  23. Brant, P., Speca, A.N. (1987). Electron spin resonance, titanium oxidation state, and ethylene polymerization studies of a model supported Ziegler-Natta catalyst. Spectroscopic detection of titanium tetrachloride. Macromolecules, 20: 2740-2744
  24. Chu, K.-J., Chang, H.-S., Ihm, S.-K. (1994). Effects of diethyl aluminum chloride (DEAC) addition to the catalysts prepared by reduction of TiCl4 with EtMgCl on ethylene-propylene copolymerization. Eur. Polym. J., 30: 1467-1472
  25. Křižan, M., Honzíček, J., Vinklárek, J., Růžičková, Z., Erben, M. (2015). Titanocene (III) pseudohalides: an ESR and structural study. New J. Chem., 39: 576-588
  26. Stukalov, D.V., Zilberberg, I.L., Zakharov, V.A. (2009). Surface species of titanium (IV) and titanium(III) in MgCl2-supported Ziegler-Natta catalysts. A periodic density functional theory study. Macromolecules, 42: 8165-8171
  27. Han‐Adebekun, G., Ray, W. (1997). Polymerization of olefins through heterogeneous catalysis. XVII. Experimental study and model interpretation of some aspects of olefin polymerization over a
  28. TiCl4/MgCl2 catalyst. J. Appl. Polym. Sci., 65: 1037-1052
  29. Ludlum, D., Anderson, A., Ashby, C. (1958). The Polymerization of Ethylene by Lower Valent Compounds of Titanium. J. American Chemical Society., 80: 1380-1384
  30. Kageyama, K., Tamazawa, J.-i., Aida, T. (1999). Extrusion polymerization: catalyzed synthesis of crystalline linear polyethylene nanofibers within a mesoporous silica. Science., 285: 2113-2115

Last update:

No citation recorded.

Last update:

No citation recorded.