DOI: https://doi.org/10.9767/bcrec.20737

Membrane-Assisted Cell Retention for Intensified Continuous Bioethanol Production

1Chemical Engineering Department, Institut Teknologi Bandung, Jl. Ganesha 10, Bandung, 40132, Indonesia

2Downstream Processing Laboratory, Research Center for Biosciences and Biotechnology, Institut Teknologi Bandung, Jl. Ganesha 10, Bandung, 40132, Indonesia

Received: 14 May 2026; Revised: 19 Jul 2026; Accepted: 20 Jul 2026; Available online: 21 Jul 2026; Published: 26 Dec 2026.
Editor(s): Istadi Istadi
Open Access Copyright (c) 2026 by Authors, Published by BCREC Publishing Group
Creative Commons License This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.
Fulltext View|Download

Citation Format:
Cover Image
Abstract

Continuous ethanol fermentation can achieve higher volumetric productivity than batch operation, but its performance is often limited by yeast washout, incomplete glucose conversion, and reduced fermentative activity under high-substrate and ethanol-stress conditions. This study evaluated an ultrafiltration membrane bioreactor for continuous ethanol fermentation using cell retention and controlled aeration. Glucose fermentation by Saccharomyces cerevisiae was evaluated in batch mode, conventional continuous anaerobic operation, anaerobic membrane bioreactor operation at dilution rates of 0.05 and 0.10 h⁻¹, and aerobic membrane bioreactor operation at 0.10 h⁻¹ with aeration rates of 0.08–0.30 vvm. Batch fermentation provided a reference for interpreting the continuous experiments: aerobic operation increased the final ethanol concentration from 65.7 to 89.5 g.L⁻¹ and the apparent maximum ethanol formation rate from 1.17 to 2.60 g.L⁻¹.h⁻¹, based on modified Gompertz fitting. In continuous operation, membrane-assisted cell retention reduced washout and increased biomass retention, glucose conversion, ethanol concentration, and volumetric productivity. At the same dilution rate of 0.10 h⁻¹, the anaerobic membrane bioreactor increased ethanol concentration from 2.8 ± 0.8 g.L⁻¹ to 43.4 ± 2.1 g.L⁻¹ and productivity from 0.3 ± 0.1 g.L⁻¹ h⁻¹ to 4.3 ± 0.2 g.L⁻¹.h⁻¹ relative to the non-membrane reactor. Lower dilution rate favored ethanol accumulation, whereas higher dilution rate favored volumetric productivity. Controlled aeration further enhanced productivity, reaching 5 g.L⁻¹.h⁻¹ at 0.08 vvm, but excessive aeration increased biomass accumulation while reducing ethanol yield and selectivity. Copyright © 2026 by Authors, Published by BCREC Publishing Group. This is an open access article under the CC BY-SA License (https://creativecommons.org/licenses/by-sa/4.0).

Supporting Information (SI) PDF
Keywords: Bioethanol; Fermentation; Reactor integration; Ultrafiltration; Operation mode; Dilution rate

Article Metrics:

Article Info
Section: Original Research Articles
Language : EN
Recent articles
Microwave-Assisted Synthesis of Bismuth Silicate (Bi2SiO5) from Natural Tunisian Sand for Efficient Solar Photocatalytic Degradation of Rhodamine B Synthesis and Characterization of Zeolite–Chitosan Composite from North Toraja Montmorillonite Mineral: Kinetic and Isotherm Study for Cu2+ Metal Ion Adsorption Membrane-Assisted Cell Retention for Intensified Continuous Bioethanol Production More recent articles
  1. The International Energy Agency (IEA). (n.d.). Biofuels. URL https://www.iea.org/reports/renewables-2024/renewable-fuels
  2. The International Energy Agency (IEA). (n.d.). Renewable fuels. URL https://www.iea.org/energy-system/low-emission-fuels/biofuels
  3. The International Energy Agency (IEA). (n.d.). Renewables 2024: Analysis and forecast to 2030
  4. Kazmi, A., Sultana, T., Ali, A., Nijabat, A., Li, G., Hou, H. (2025). Innovations in bioethanol production: A comprehensive review of feedstock generations and technology advances. Energy Strategy Reviews, 57, 101634. DOI: 10.1016/j.esr.2024.101634
  5. Sahana, G.R., Balasubramanian, B., Joseph, K.S., Pappuswamy, M., Liu, W.-C., Meyyazhagan, A., Kamyab, H., Chelliapan, S., Joseph, B.V. (2024). A review on ethanol tolerance mechanisms in yeast: Current knowledge in biotechnological applications and future directions. Process Biochemistry, 138, 1–13. DOI: 10.1016/j.procbio.2023.12.024
  6. Tsegaye, K.N., Alemnew, M., Berhane, N. (2024). Saccharomyces cerevisiae for lignocellulosic ethanol production: a look at key attributes and genome shuffling. Frontiers in Bioengineering and Biotechnology, 12, 1466644. DOI: 10.3389/fbioe.2024.1466644
  7. Qin, Y., Zhai, C. (2024). Global Stabilizing Control of a Continuous Ethanol Fermentation Process Starting from Batch Mode Production. Processes, 12 (4), 819. DOI: 10.3390/pr12040819
  8. Alqahtani, R.T., Bhowmik, S.K., Ajbar, A., Boumaza, M. (2021). Stability and Performance Analysis of Bioethanol Production with Delay and Growth Inhibition in a Continuous Bioreactor with Recycle. Processes, 9 (3), 461. DOI: 10.3390/pr9030461
  9. Domingo-Félez, C., Jankowska, K., Skiadas, I.V., Woodley, J.M., Pinelo, M. (2023). Continuous ethanol production via ultrasound-enhanced yeast sedimentation. Food and Bioproducts Processing, 140, 181–188. DOI: 10.1016/j.fbp.2023.06.002
  10. Wang, F.-S., Li, C.-C., Lin, Y.-S., Lee, W.-C. (2013). Enhanced ethanol production by continuous fermentation in a two-tank system with cell recycling. Process Biochemistry, 48 (9), 1425–1428. DOI: 10.1016/j.procbio.2013.06.023
  11. Chang, H.N., Yoo, I.-K., Kim, B.S. (1994). High density cell culture by membrane-based cell recycle. Biotechnology Advances, 12 (3), 467–487. DOI: 10.1016/0734-9750(94)90020-5
  12. Hoffmann, H., Scheper, T., Schügerl, K., Schmidt, W. (1987). Use of membranes to improve bioreactor performance. The Chemical Engineering Journal, 34 (1), B13–B19. DOI: 10.1016/0300-9467(87)85010-4
  13. Ylitervo, P., Franzén, C., Taherzadeh, M. (2014). Continuous Ethanol Production with a Membrane Bioreactor at High Acetic Acid Concentrations. Membranes, 4 (3), 372–387. DOI: 10.3390/membranes4030372
  14. Wei, P., Cheng, L.-H., Zhang, L., Xu, X.-H., Chen, H., Gao, C. (2014). A review of membrane technology for bioethanol production. Renewable and Sustainable Energy Reviews, 30, 388–400. DOI: 10.1016/j.rser.2013.10.017
  15. Jiang, H., Han, L., Liu, W., Zhang, Y., Liu, J., Xiao, Z., Fan, S. (2025). Bioethanol production from cassava fed-batch fermentation in pervaporation membrane bioreactor with permeate fractional condensation. Separation and Purification Technology, 354, 128807. DOI: 10.1016/j.seppur.2024.128807
  16. Liu, J., Zhang, Y., Liu, W., Jiang, H., Han, L., Xiao, Z., Fan, S. (2025). Pilot plant design and technology performance analysis of pervaporation membrane bioreactor with mechanical vapor compression for bioethanol production. Chinese Journal of Chemical Engineering, 82, 57–66. DOI: 10.1016/j.cjche.2025.02.026
  17. Nassif, A.G., Ibrahim, S.S., Majdi, H.Sh., Alsalhy, Q.F. (2022). Ethanol Separation from an Ethanol–Water Solution Using Vacuum Membrane Distillation. Membranes, 12 (8), 807. DOI: 10.3390/membranes12080807
  18. Mahajan, Y.S., Jadhav, H.R. (2025). Use of membrane distillation for selective recovery of chemicals like ethyl alcohol: a critical review. Chemical Product and Process Modeling, 21(3), 357-377. DOI: 10.1515/cppm-2025-0023
  19. Mokaram, M.M., Esfahanian, M. (2025). Bioethanol fermentation integrated with PDMS membrane modified by carbon nanotube and graphene oxide from sugarcane bagasse. Biomass Conversion and Biorefinery, 15 (9), 13425–13439. DOI: 10.1007/s13399-024-05990-8
  20. Melzoch, K., Rychtera, M., Markvichov, N.S., Pospíchalová, V., Basařová, G., Manakov, M.N. (1991). Application of a membrane recycle bioreactor for continuous ethanol production. Applied Microbiology and Biotechnology, 34 (4), 469–472. DOI: 10.1007/BF00180572
  21. Liu, C.-G., Hao, X.-M., Lin, Y.-H., Bai, F.-W. (2016). Redox potential driven aeration during very-high-gravity ethanol fermentation by using flocculating yeast. Scientific Reports, 6 (1), 25763. DOI: 10.1038/srep25763
  22. Lin, Y.-H., Chien, W.-S., Duan, K.-J., Chang, P. R. (2011). Effect of aeration timing and interval during very-high-gravity ethanol fermentation. Process Biochemistry, 46 (4), 1025–1028. DOI: 10.1016/j.procbio.2011.01.003
  23. Lebaka, V.R., Ryu, H.-W., Wee, Y.-J. (2014). Effect of fruit pulp supplementation on rapid and enhanced ethanol production in very high gravity (VHG) fermentation. Bioresources and Bioprocessing, 1 (1), 22. DOI: 10.1186/s40643-014-0022-8
  24. Girardi Piva, G., Casalta, E., Legras, J.-L., Tesnière, C., Sablayrolles, J.-M., Ferreira, D., Ortiz-Julien, A., Galeote, V., Mouret, J.-R. (2022). Characterization and Role of Sterols in Saccharomyces cerevisiae during White Wine Alcoholic Fermentation. Fermentation, 8 (2), 90. DOI: 10.3390/fermentation8020090
  25. Zara, G., Van Vuuren, H. J. J., Mannazzu, I., Zara, S., Budroni, M. (2019). Transcriptomic Response of Saccharomyces cerevisiae during Fermentation under Oleic Acid and Ergosterol Depletion. Fermentation, 5 (3), 57. DOI: 10.3390/fermentation5030057
  26. Dodić, J.M., Vučurović, D.G., Dodić, S.N., Grahovac, J.A., Popov, S.D., Nedeljković, N.M. (2012). Kinetic modelling of batch ethanol production from sugar beet raw juice. Applied Energy, 99, 192–197. DOI: 10.1016/j.apenergy.2012.05.016
  27. Rorke, D., Gueguim Kana, E. (2017). Kinetics of Bioethanol Production from Waste Sorghum Leaves Using Saccharomyces cerevisiae. Fermentation, 3 (2), 19. DOI: 10.3390/fermentation3020019
  28. Henderson, C.M., Block, D.E. (2014). Examining the Role of Membrane Lipid Composition in Determining the Ethanol Tolerance of Saccharomyces cerevisiae. Applied and Environmental Microbiology, 80 (10), 2966–2972. DOI: 10.1128/AEM.04151-13
  29. Kargupta, K., Datta, S., Sanyal, S.K. (1998). Analysis of the performance of a continuous membrane bioreactor with cell recycling during ethanol fermentation. Biochemical Engineering Journal, 1 (1), 31–37. DOI: 10.1016/S1369-703X(97)00006-5
  30. Brandberg, T., Sanandaji, N., Gustafsson, L., Johan Franzén, C. (2008). Continuous Fermentation of Undetoxified Dilute Acid Lignocellulose Hydrolysate by Saccharomycescerevisiae ATCC 96581 Using Cell Recirculation. Biotechnology Progress, 21 (4), 1093–1101. DOI: 10.1021/bp050006y
  31. Oliveira, S.C., Gonçalves, R.H., Veloso, I.I.K. (2025). Mathematical Modeling of a Continuous Multistage Ethanol Production Bioprocess on an Industrial Scale. Biomass, 5 (4), 65. DOI: 10.3390/biomass5040065
  32. Yan, G., Zhang, B., Joseph, L., Waterhouse, A.L. (2020). Effects of initial oxygenation on chemical and aromatic composition of wine in mixed starters of Hanseniaspora vineae and Saccharomyces cerevisiae. Food Microbiology, 90, 103460. DOI: 10.1016/j.fm.2020.103460
  33. Liu, C.-G., Wang, N., Lin, Y.-H., Bai, F.-W. (2012). Very high gravity ethanol fermentation by flocculating yeast under redox potential-controlled conditions. Biotechnology for Biofuels, 5 (1), 61. DOI: 10.1186/1754-6834-5-61
  34. Liu, C.-G., Hao, X.-M., Lin, Y.-H., Bai, F.-W. (2016). Redox potential driven aeration during very-high-gravity ethanol fermentation by using flocculating yeast. Scientific Reports, 6 (1), 25763. DOI: 10.1038/srep25763
  35. Nakao, S., Saitoh, F., Asakura, T., Toda, K., Kimura, S. (1987). Continuous ethanol extraction by pervaporation from a membrane bioreactor. Journal of Membrane Science, 30 (3), 273–287. DOI: 10.1016/S0376-7388(00)80123-4
  36. Elhalis, H. (2024). Expanding the Horizons of Saccharomyces cerevisiae: Nutrition, Oenology, and Bioethanol Production. Sustainability, 16 (24), 11151. DOI: 10.3390/su162411151
  37. Ji, X.-X., Zhang, Q., Yang, B.-X., Song, Q.-R., Sun, Z.-Y., Xie, C.-Y., Tang, Y.-Q. (2025). Response mechanism of ethanol-tolerant Saccharomyces cerevisiae strain ES-42 to increased ethanol during continuous ethanol fermentation. Microbial Cell Factories, 24 (1), 33. DOI: 10.1186/s12934-025-02663-7
  38. Westman, J.O., Franzén, C.J. (2015). Current progress in high cell density yeast bioprocesses for bioethanol production. Biotechnology Journal, 10 (8), 1185–1195. DOI: 10.1002/biot.201400581
  39. Carstensen, F., Wessling, M. (2014). In situ product recovery from fermentation processes using reverse flow diafiltration. Lehrstuhl für Chemische Verfahrenstechnik und Institut für Verfahrenstechnik
  40. Ylitervo, P., Franzén, C., Taherzadeh, M. (2013). Impact of Furfural on Rapid Ethanol Production Using a Membrane Bioreactor. Energies, 6 (3), 1604–1617. DOI: 10.3390/en6031604
  41. Olga Radočaj, Levente L. Diosady. (2014). Continuous Ethanol Fermentation in Immersed, Cross-Flow Microfiltration Membrane Bioreactor with Cell Retention. Journal of Basic & Applied Sciences, 10, 543–553. DOI: 10.6000/1927-5129.2014.10.73

Last update:

No citation recorded.

Last update:

No citation recorded.